What kind of concrete work is common in Dade County?

The county's livestock economy and small manufacturing base split the work a few ways. Cattle and hay operations drive farm-shop slabs and equipment pads, often 6 to 8 inches with #4 rebar sized off the equipment. Manufacturing, the county's largest employment sector at about 511 jobs, drives plant and warehouse floors at 4,000 PSI. Greenfield and Lockwood lots carry standard 4-inch residential drives and patios on a compacted crushed-stone base.

How does Dade County soil affect a slab?

Dade County sits on the western Ozark Plateau over Burlington-Keokuk limestone, with clay-rich soils on the Sac River bottoms that swell wet and shrink dry. The durable build compacts the subgrade to about 95 percent Proctor density and lays 4 to 6 inches of crushed-stone base, with exterior pours air-entrained at 5 to 7 percent for the roughly 80 freeze-thaw cycles the region averages. On an older slab, a Sac River bottomland or Stockton Lake shoreline parcel, or a floor with a prior coating failure, on-site moisture testing is added before a coating goes down, because vapor drive through a damp slab is what lifts coatings.

What does a cabin or outbuilding slab near Stockton Lake in Dade County need?

A 4 to 6 inch slab on a well-drained base is the usual build for cabin floors, patios, and outbuildings along the Stockton Lake shoreline and the Sac River bottoms. That is lighter than a farm-shop pour, which runs 6 to 8 inches with #4 rebar for loaders and balers. Exterior concrete here carries 5 to 7 percent entrained air against roughly 80 freeze-thaw cycles a winter.

Concrete in Dade county, MO

Q: Which Dade County towns does Bel Covo serve?

Bel Covo covers Dade County towns with dedicated pages anchored by Greenfield, the county seat at roughly 1,316 residents, and Lockwood, the western farm town of about 905 on US Route 160. Greenfield anchors the civic and commercial work where Route 160 meets Route 39, and the surrounding rural acreage and smaller communities are served under the same Ozarks coverage. The town rail on this page links every covered Dade County town.

Concrete across Dade county

Concrete Dade County work spans a wide rural map. Bel Covo serves 2 towns across it with one crew that both pours and finishes, so driveways, shop and barn slabs, garage floor coatings, and polished concrete all stay under a single contractor instead of two. Pour to finish, one schedule.

Dade County is the Sac River cattle-and-hay county on the western edge of the Ozark Plateau, anchored by Greenfield, the county seat platted in 1841. About a dozen rural communities hold the county’s roughly 7,400 residents, and the economy runs on livestock, hay ground, and a manufacturing base that is the county’s single largest employment sector at about 511 jobs. That mix puts farm-shop slabs, equipment pads, and small-plant floors at the center of the concrete work, with US Route 160 and Route 39 carrying most of it.

Which Dade county towns does Bel Covo serve?

Greenfield, the county seat since 1841, anchors the civic and commercial work, while Lockwood (founded 1881 on the railroad) holds down the county’s western farm-town corner on US Route 160. The town rail below links each covered Dade County town.

Greenfield, the county seat platted in 1841 where Route 160 meets Route 39
Lockwood, the 1881 railroad farm town on US Route 160 in the county’s west

Every covered Dade County town has a link in the rail below, and the open country between them falls under the same Ozarks reach.

Why does a county-wide crew change a Dade County job?

Dade County runs from the Stockton Lake shoreline on its northeast corner across open hay ground to the Lockwood farm belt on US Route 160, and one Bel Covo crew pours and finishes across that whole spread rather than handing a slab between trades. A cattle-operation shop pad outside Greenfield and a small-plant floor in town both get the same crew that has placed concrete on Ozark Plateau soil for two decades. Scheduling across the covered towns is run off one calendar under our Ozarks coverage, so a rural owner with work at more than one address is not juggling separate contractors.

What does concrete work look like across Dade County?

The county’s livestock economy and small manufacturing base sort the concrete work into a few clear types.

Farm-shop slabs and equipment pads. Cattle and hay operations run loaders, balers, and grain carts onto shop floors, so these pour at 6 to 8 inches with #4 rebar sized off the equipment list rather than a generic residential spec.
Light-manufacturing and warehouse floors. Manufacturing is the county’s largest employment sector at roughly 511 jobs, driving plant and warehouse floors at 4,000 PSI finished to ACI 302.1R flatness tolerances for forklift traffic.
Residential drives and patios. Greenfield and Lockwood lots carry the standard 4-inch slab on a compacted crushed-stone base, with exterior pours air-entrained at 5 to 7 percent against the roughly 80 freeze-thaw cycles a western-Ozark winter brings.
Garage and shop coatings. The residential and light-commercial market takes epoxy and polyaspartic systems at 4 to 20 mils over a properly ground slab.
Lake-edge and rural flatwork. Properties near the Stockton Lake shoreline and along the Sac River bottoms add cabin slabs, patios, and outbuilding floors, typically 4 to 6 inches on a well-drained base.

How does the Sac River bottomland and Burlington-Keokuk limestone under Dade county behave?

Dade County sits on the western Ozark Plateau, where Mississippian-age Burlington-Keokuk limestone is the dominant bedrock and the source of most local crushed-stone coarse aggregate; Sac River and tributary alluvium supplies the fine aggregate for ready-mix in the county. That limestone carries fossils, so polished floors here show crinoid columnals and brachiopod fragments at medium exposure, with darker chert nodules reading as natural speckle against the bright limestone ground. The slab still lives or dies on the prep below it: compact the subgrade to about 95 percent standard Proctor density and place 4 to 6 inches of crushed-stone base for drainage and load spread. We air-entrain every exterior pour at 5 to 7 percent for the roughly 80 freeze-thaw cycles this western-Ozark belt averages each winter, with the cold-weather window running October through April.

The concrete durability guide walks through how the mix and prep hold up over decades.

See what your Dade County concrete costs

Give us the square footage, how the slab gets used, and the site conditions anywhere in Dade County; the quote tool prices it in about two minutes.

Price your project